Safety Data Sheet SDS VASARI WAX
Manufacturer / distributor information:
Vasari Lime Plaster & Paint llc
115 N. Olive St.
Ventura, CA, 93001
Telephone: (805) 667-8454
Prepared December 4, 2023 by Vasari Lime Plaster & Paint llc
website: www.vasariplaster.com
24 hour emergency – Chemtrec 1-800-424-9300
I. Identification and Product Names
Product Names: Vasari Wax
Trade Names: carnauba based wax
Product used for sealing and rejuevanting wood, plaster, metal, concrete and mineral surfaces.
II. Chemical Composition
Toxicity:
The ingredients in this formula have been reviewed and no adverse affects impact to the environment is expected when used according to label directions. No off gassing or VOCs have been detected.
Classification of the substance or mixture
Flam. Liq. 4;H227 Combustible Liquid.
Skin Irrit. 3;H316 Causes mild skin irritation. (Note: this GHS classification was not adopted by US
OSHA).
Skin Sens. 1;H317 May cause an allergic skin reaction.
Aquatic Chronic 2;H411 Toxic to aquatic life with long lasting effects
Label elements
H227 Combustible liquid.
H316 Causes mild skin irritation.
H411 Toxic to aquatic life with long lasting effects.
[Prevention]
P210 Keep away from heat, sparks, open flames, and other ignition sources - No smoking.
P235 Keep cool.
P261 Avoid breathing dust, fume, gas, mist, vapors, spray.
P272 Contaminated work clothing should not be allowed out of the workplace.
P273 Avoid release to the environment.
P280 Wear protective gloves, eye protection, face protection.
[Response]
P302+352 IF ON SKIN: Wash with plenty of soap and water.
P321 Specific treatment (see information on this label).
P362 Take off contaminated clothing and wash before reuse.
P370+378 In case of fire: Use extinguishing media listed in section 5 of SDS for extinction.
P391 Collect spillage.
[Storage]
P403+235 Store in a well ventilated place. Keep cool.
[Disposal]
P501 Dispose of contents or container in accordance with local and national regulations
III. Composition/information on ingredients (see PDF above)
IV. First Aid Measures for Accidental Exposure:
DANGER! HARMFUL IF SWALLOWED OR INHALED. CAUSES BURNS TO SKIN AND EYES. CAUSES SEVERE IRRITATION TO RESPIRATORY TRACT. INHALATION CANCER HAZARD.
Inhalation Remove to fresh air, keep patient warm and at rest. If breathing is irregular or stopped, give
artificial respiration. If unconscious, place in the recovery position and obtain immediate
medical attention. Give nothing by mouth.
Eyes Make sure to remove any contact lenses from the eyes before rinsing. Promptly wash eyes
with plenty of water while lifting the eye lids. Continue to rinse for at least 15 minutes. Get
medical attention if any discomfort continues.
Skin Remove contaminated clothing. Wash skin thoroughly with soap and water or use a
recognized skin cleanser.
Ingestion If victim is conscious and alert, give 2-4 cupfuls of milk or water. DO NOT INDUCE
VOMITING.
Most important symptoms and effects, both acute and delayed
Overview
Inhalation hazard, only if dust if created. Treat symptomatically. Exposure to solvent vapor
concentrations from the component solvents in excess of the stated occupational exposure
limits may result in adverse health effects such as mucous membrane and respiratory
system irritation and adverse effects on the kidneys, liver and central nervous system.
Symptoms include headache, nausea, dizziness, fatigue, muscular weakness, drowsiness
and in extreme cases, loss of consciousness.
Repeated or prolonged contact with the preparation may cause removal of natural fat from
the skin resulting in dryness, irritation and possible non-allergic contact dermatitis. Solvents
may also be absorbed through the skin. Splashes of liquid in the eyes may cause irritation
and soreness with possible reversible damage. Check section 2.2 (GHS Label Elements)
for further details.
Skin May cause an allergic skin reaction. Causes mild skin irritation. (Note: this GHS
classification was not adopted by US OSHA).
V. Fire Fighting Measures
Extinguishing media
Use media appropriate for surrounding area.
Special hazards arising from the substance or mixture
Hazardous decomposition: High temperatures and fires may produce such toxic substances as carbon monoxide and carbon dioxide.
Keep away from heat, sparks, open flames, and other ignition sources.
Keep cool.
Avoid breathing dust, fume, gas, mist, vapors, spray.
Advice for fire-fighters
Use water spray, alcohol resistant foam, dry chemical or carbon dioxide.
Fight fire with normal precautions from a reasonable distance.
VI. Accidental Release Measures
Cleanup and Disposal of Spill:
Personal precautions, protective equipment and emergency procedures
Put on appropriate personal protective equipment (see section 8).
Environmental precautions
Use good personal hygiene practices. Wash hands before eating, drinking, smoking or using toilet. Promptly remove
soiled clothing and wash thoroughly before reuse.
Methods and material for containment and cleaning up
Wipe up with cloth or sponge. Sweep or shovel residue.
VII. Handling and Storage
Handling:
Precautions for safe handling
Store in a cool dry place.
Store in accordance with the National Fire Protection Association's publication NFPA 30, Flammable and
Combustible Liquids Code. 29 CFR 1910.106 applies to the handling, storage, and use of flammable and combustible liquids.
Check section 2.2 (GHS Label Elements) for further details. - [Prevention]
Conditions for safe storage, including any incompatibilities
Store in a cool dry area, away from heat, sparks and open flame.
Keep containers sealed when not in use.
Store out of direct sunlight.
Incompatible materials: Strong oxidizing agents and acids.
VIII. Exposure Controls / Personal Protection
Exposure Guidelines:
Due to the encapsulated form of these products, no exposure to the components in the products is anticipated under normal use conditions.
Engineering Controls:
Ventilation must be adequate to maintain the ambient workplace atmosphere below OSHA exposure limit(s).
Respiratory Protection:
Follow the OSHA respirator regulations found in 29CFR 1910.134 or European Standard EN 149. Always use a NIOSH/MSA approved respirator when necessary.
Eye / Face Protection:
Wear safety glasses with side shields or goggles.
Skin Protection:
Not applicable
Other Work Practices:
Use good personal hygiene practices. Wash hands before eating, drinking, smoking or
using toilet. Promptly remove soiled clothing and wash thoroughly before reuse.
IX. Physical and Chemical Properties
Appearance Color: Light yellow or white Physical State: Waxy paste
Odor threshold Not Available
pH Not Established
Melting point / freezing point 175 F / 26 F
Initial boiling point and boiling range 340-399 F
Flash Point 159.6 F
Evaporation rate (Ether = 1) Not Established
Flammability (solid, gas) Not Applicable
Upper/lower flammability or explosive limits Lower Explosive Limit: Not Established
Upper Explosive Limit: Not Established
Vapor pressure (Pa) Not Established
Vapor Density Not Established
Relative Density 0.886
Solubility in Water Not Measured
Partition coefficient n-octanol/water (Log Kow) Not Measured
Auto-ignition temperature Not Established
Decomposition temperature Not Established
Viscosity (cSt) Not Established
VOC Content Not Established
X. Stability and Reactivity
Reactivity
Hazardous Polymerization will not occur.
Chemical stability
Stable under normal circumstances.
Possibility of hazardous reactions
No data available.
Conditions to avoid
Excessive heat and open flame.
Incompatible materials
Strong oxidizing agents and acids.
Hazardous decomposition products
High temperatures and fires may produce such toxic substances as carbon monoxide and carbon dioxide
Hazardous Polymerization: ND
XI. Toxicological Information
Carcinogenicity: ND
Exposure to solvent vapor concentrations from the component solvents in excess of the stated occupational exposure limits may result in adverse health effects such as mucous membrane and respiratory system irritation and adverse effects on the kidneys, liver and central nervous system. Symptoms include headache, nausea, dizziness, fatigue,muscular weakness, drowsiness and in extreme cases, loss of consciousness.
Repeated or prolonged contact with the preparation may cause removal of natural fat from the skin resulting in
dryness, irritation and possible non-allergic contact dermatitis. Solvents may also be absorbed through the skin.
Splashes of liquid in the eyes may cause irritation and soreness with possible reversible damage.
XII. Ecological Information
Ecotoxicological Information:
Eco-toxicity:
The ingredients in this formula have been reviewed and no adverse affects impact to the environment is expected when used according to label directions. No detectable off gassing or VOCs have been detected. The toxicity of this material to aquatic organisms has not been evaluated. Consequently, this material should be kept out of sewage and drainage systems and all bodies of water.
Persistence and degradability
There is no data available on the preparation itself.
Bioaccumulative potential
Not Measured
Mobility in soil
No data available.
Results of PBT and vPvB assessment
This product contains no PBT/vPvB chemicals.
Other adverse effects
XIII. Disposal Considerations
Waste Disposal Method:
Dispose of in accordance with federal, state and local regulations.
XIV. Transportation Information
Freight Class: 70
Handling unit: 3405.20.0000
NMFC Code: 196880
Harmonized code: 3405.20.00
|
US Department of Transportation Shipping Name: US Department of Transportation |
Proper Shipping Name: None |
Air Class: None |
|
|
Hazard Class |
None |
||
|
ID Number |
None |
||
|
Packaging Group |
None |
||
Domestic (USDOT) International (IMDG) Air (IATA) TDG (Canada)
UN Number: Not regulated
Environmental Hazard Class: None
Sea Transport: Not regulated
Air Transport: Not regulated
Special Precautions for User: None
IMDG code (The International Maritime Dangerous Goods): Not applicable
XV. Regulatory information US federal regulations
TSCA: The components of this mixture are listed or are exempt from listing in the Toxic Substance Control Act Inventory of Chemical Substances. This product does not contain any chemicals that would require export notification under Section 12(b) of the TSCA regulation. This product contains no: Cadmium (Cd), Chromium (Cr), Lead (Pb), Tin (Sn), nor any organic elements that can cause cancer. This product contains no ozone-depleting compounds
XVI. Other information
Date of preparation or last revision Issue date
December 4, 2023
Vasari Lime Plaster & Paint llc provides the information contained herein in good faith but makes no representation as to its comprehensiveness or accuracy. This document is intended only as a guide to the appropriate precautionary handling of the material by a properly trained person using this product. Individuals receiving the information must exercise their independent judgment in determining its appropriateness for a particular purpose. Vasari Lime Plaster & Paint MAKES NO REPRESENTATIONS OR WARRANTIES, EITHER EXPRESS OR IMPLIED, INCLUDING WITHOUT LIMITATION ANY WARRANTIES OF MERCHANTABILITY, FITNESS FOR A PARTICULAR PURPOSE WITH RESPECT TO THE INFORMATION SET FORTH HEREIN OR THE PRODUCT TO WHICH THE INFORMATION REFERS. ACCORDINGLY, Vasari Lime Plaster & Paint WILL NOT BE RESPONSIBLE FOR DAMAGES RESULTING FROM USE OF OR RELIANCE UPON THIS INFORMATION.
Prepared by:
Product Safety
Vasari Lime Plaster & Paint llc
115 N. Olive St.
Ventura, CA, 93001